|
20 |
|
 |
*00-III
To search this page please hit
CTRL+F on your Keyboard
GROUP 20 INDEX
-----------------------
DIAGRAM 1 0000 900621
ENGINE COOLING SYSTEM, PRESS. TEST 1010 940407
ENGINE COOLANT, FLUSH / REPL. 1030 950731
ANTIFREEZE-WATER RATIO, CORRECT 1150 950731
ENGINE COOLANT PUMP 1290 950731
ENG. COOLANT PUMP PULLEY 1660 950731
ENG. COOLANT PUMP INLET COVER 1715 950731
ENG. COOLANT PUMP HOUSING 2155 950731
COOLANT THERMOSTAT/GASKET 2470 950731
COOLANT THERMOSTAT HOUSING/COVER 2720 950731
ENG. COOLANT TEMP. SWITCH - FOR TEMP. GAUGE 3710 940923
ENGINE COOLANT LEVEL SENSOR 3733 920626
RADIATOR & CAP 3865 940914
RADIATOR SIDES AND BOTTOM COVERING 4510 970905
COOLANT EXPANSION TANK 4950 940914
COOLANT OVERFLOW TANK 5410 950731
ENGINE BLOCKHEATER/CABLE 5470 971209
ENGINE COOLING FAN 5660 920626
ENGINE COOLING FAN MOUNTING FIXTURE 5995 950817
ENGINE COOLING FAN CONTROL MODULE 6000 970924
COOLING FAN COUPLING/VISCOUS FAN CLUTCH 6590 920204
ENGINE COOLING FAN TEMP. SWITCH 6721 970924
ENGINE COOLING FAN SHROUD 6800 940914
COOLANT HOSES - ENGINE 7440 900608
COOLANT HOSES - HEATING SYSTEM 8240 900608
COOLANT HOSES - FOR WINDSHIELD HEATER 8852 971031
COOLANT PIPE/LINE - ENGINE COOLING SYST. 9110 971031
CONNECTOR FOR HEATER HOSE - AT CYL. HEAD 9430 971031
COOLANT OVERFLOW FITTING ON RADIATOR 9472 931216
INCLUDED OPERATIONS AS REQUIRED
20- B EFF DATE: 11-01-03
+ 20-D01
+ 20-TTT
-
ENGINE COOLING SYSTEM, PRESS. TEST
---------------------
20-1010 * ENG. COOLING & HEAT. SYST., PRESS.TEST FOR LEAKS/DETER.COND. .3 00
ENGINE COOLANT, FLUSH / REPL.
--------------
20-1030 * ENGINE COOLING SYSTEM, FLUSH .0 N0
.0 T3/U0
.8 C0/G0/H0/20/25/30
40/80
A1/A5/E2/E6/E7/E8
E9/P0/Q0/S1/S4/T1
T4/56/57/61/62/63
64/65/74/75/78/79
1.0 B1/B2/E1/E3/E4/E5
S2/S3/S5/S6/T2/T5
91/95
1.2 A2/A3/A7/A8/B3/B7
B8
1.4 10
51/52/53/54/55/71
72/73
1.5 92/93/96/98
1.6 A4/A9/B4/B9/67/68
94/97
20-002 EFF DATE: 11-01-03
+ 20-TTT
-
20-1140 * ENGINE COOLANT, REPLACE AND CHECK FOR LEAK(S) .4 C0/E0/G0/H0/M0/N0
20/25/30/40/80
A1/A5/B1/B2/F0/J1
P1/P2/P3/P4/P5/P6
P7/P8/P9/Q1/Q2/Q3
Q4/S1/S2/S3/S4/S5
S6/61/62/63/64/65
91/95/98
.6 10/50/70
A2/A3/A7/A8/B3/B7
B8/R1/R2/67/68/92
93/96
.7 A4/A9/B4/B9/94/97
1.0 T1/T2/T3/T4/T5/U0
ANTIFREEZE-WATER RATIO, CORRECT
----------------------
20-1150 * ANTIFREEZE-WATER RATIO, CORRECT AND CHECK FOR LEAK(S) .3 00
20-003 EFF DATE: 11-01-03
+ 20-TTT
-
ENGINE COOLANT PUMP
-------------------
20-004 EFF DATE: 11-01-03
+ 20-TTT
-
20-1290 * ENGINE COOLANT PUMP, R & R / REPL. IF REQ. 1.3 C1/C4/21/31/42
(SEE ALSO 20-1514/1535) - ADDL. WORK M.I. 21/31/32/33/85 1.4 A5/32/33/35/36/37
56
1.5 Q1
1.6 P5
1.7 E1/E5/U1/U4
1.8 C7/G1/G2/Q3/86
2.0 S1/S2/S3/S4/T1/T4
61
2.1 C5/C6/E4/E6/E7/E8
E9/F1/F2/H1/H3/S5
S6/U2/U3
2.3 T2/T5/41/43/46/47
57/78/79/81/87
2.4 G3/G4/P1/P2/P3/P4
P6/P7/P8/P9/Q2/Q4
2.5 H2/H4/H5/H6/M4/M8
N2/N4/R1/R2/22/23
98
2.6 T3
2.7 E2
2.8 J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5/44
94/97
2.9 B1/B2
3.3 A1/A2/A3/A7/B3/B7
C2/C3/E3/62/63/64
65/89
3.4 93/96
3.6 A4/A9/B4/B9
3.8 A8/B8/74/75/92
3.9 82/83/84/85/88
4.2 25
45
4.3 51/52/53/54/55/67
68/71/72/73
4.5 91/95
4.8 10
20-005 EFF DATE: 11-01-03
+ 20-TTT
-
20-1295 * ENG. COOLANT PUMP - (RADIATOR REMOVED), R & R / REPL. IF REQ .7 A5/Q1
(SEE ALSO 20-1514/1535) - ADDL. WORK M.I. 21/31/32/33/85 .8 C1/C4/C7/E1/E5/G1
G2/P5
.9 Q3/42/43/46/61
1.0 U1/U4
1.1 M8
1.2 C6/E4/E6/E7/E8/E9
F1/F2/S1/T1/T4
1.3 H0
C5/G3/G4/M4/N2/N4
S2/S3/S4
1.4 E2/S6/41/47/57/78
79/81/86
1.5 J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5/P1
P2/P3/P4/P6/P7/P8
P9/Q2/Q4/R1/S5/U2
U3/98
1.6 R2/T3
1.7 T2/T5/87/94/97
2.3 A4/A9/B1/B2/B4/B9
2.4 67/68
2.5 C2/C3/45
2.7 A1/A2/A3/A7/A8/B3
B7/B8/E3
2.8 11/12/15/62/63/64
65/89/92/93/96
2.9 51/52/53/54/55
3.3 74/75
3.4 26/27/82/83/84/85
88
3.6 71/72/73/91/95
20-006 EFF DATE: 11-01-03
+ 20-TTT
-
20-1300 * ENGINE COOLANT PUMP - (ENGINE REMOVED), R & R / REPL. IF REQ .4 Q1/Q3
.5 A5/E1/E5/42/43/46
57/61/78/79/81/86
87
.7 P5
.8 M8/U1/U4
.9 C1/C4/C7/G1/G2/R1
S1/S2/S3/S4/T1/T4
1.0 P1/P2/P3/P4/P6/P7
P8/P9/Q2/Q4
1.1 H0
G3/G4/M4/N2/N4/41
44/47
1.2 C5/C6/E2/E4/E6/E7
E8/E9/F1/F2/R2/S5
S6/T3/U2/U3
1.3 J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5
1.4 A1/B1/B2/T2/T5/98
1.6 25
62/63/64/65/74/75
82/83/84/85/88/89
1.7 10
51/52/53/54/55
1.8 A2/A3/A4/A7/A8/A9
B3/B4/B7/B8/B9/E3
45/67/68/93/94/96
97
1.9 91/95
2.0 71/72/73
2.2 92
2.4 C2/C3
20-1514 * ADDL. TO OPER. NO. 1290 - VEH. WITH YORK AC COMPRESSOR 1.4 21/31/32/33
20-1535 * ADDL. TO OPER. 1290/1295 - DIFFICULTIES FROM INT. MANIFOLD 2.0 85
20-007 EFF DATE: 11-01-03
+ 20-TTT
-
ENG. COOLANT PUMP PULLEY
------------------------
20-1660 * COOLANT PUMP PULLEY, R & R / REPL. IF REQ. .3 67/68
.4 B3/B7/B8/C1/C4/C7
P5/Q3/57/78/79/91
92/93/95/96
.5 40
62/63/64/65/81/86
87/89
.6 A2/A3/A5/A7/A8/C2
C3/C5/E2/E3/R1/T1
T2/T5/U1/U2/U3/U4
15/98
.7 A4/A9/C6/E1/E4/E5
E6/E7/E8/E9/F1/F2
P1/P2/P3/P4/P6/P7
P8/P9/Q2/Q4/S1/S2
S3/S4/S5/S6/26/27
61/74/75/82/83/84
85/88/94/97
.8 G0
A1/B1/B2/H1/H2/H3
H4/H5/Q1
.9 B4/B9/R2/T3
1.1 M8/11/12/13/14
1.3 M4
1.5 N2/N4
1.7 J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5
20-008 EFF DATE: 11-01-03
+ 20-TTT
-
ENG. COOLANT PUMP INLET COVER
-----------------------------
20-1715 COOLANT PUMP INLET COVER, R & R / REPL. IF REQ. .2 A1/B1/B2
(ENG. COOLANT DRAINED) .3 A2/A3/A7/A8/B3/B7
B8
.5 92/93/96
ENG. COOLANT PUMP HOUSING
-------------------------
20-2155 * ENG. COOLANT PUMP HOUSING, R & R / REPL. IF REQ. 1.5 21
(SEE ALSO 20-2300) - 123 MODEL WITH YORK A/C COMPRESSOR 2.3 E1/E5/31/32/33/34
35/36/37/56
2.5 42
2.8 86
3.1 A5
3.3 22
3.4 43/46/57/61/78/79
81/87
3.5 23
20-2156 * ENG. COOLANT PUMP HOUSING - (RADIATOR REMOVED),R & R / REPL. 1.5 E1/E5/56
1.9 42/43/46
2.1 A5
2.3 57/61/78/79/81/86
87
20-2300 * ADDL. TO OPER. 2155 - VEH. WITH YORK A/C COMPRESSOR 1.4 21/31/32/33
20-009 EFF DATE: 11-01-03
+ 20-TTT
-
COOLANT THERMOSTAT/GASKET
-------------------------
20-2470 * ENG. COOLANT THERMOSTAT/GASKET, R & R / REPL. IF REQ. .4 C0/25/40/80
E2/E3/G1/G2/57/61
62/63/64/65/74/75
78/79/91/95
.5 20/30
A1/B1/B2/56
.6 A5
.8 A2/A3/A7/A8/B3/B7
B8/92/93/96
.9 M4/U1/U2/U3/U4/51
52/54/55/71/72/73
1.0 P5/Q1/Q3/S4
1.1 10
E1/E4/E5/E6/E7/E8
E9/F1/F2/S1/S2/S3
S5/S6/T1/T2/T4/T5
1.2 A4/A9/B4/B9/G3/G4
H1/H2/H3/H4/H5/N1
N3/N5/P1/P2/P3/P4
P6/P7/P8/P9/Q2/Q4
94/97/98
1.3 J1/M1/M2/M3/M5/M6
M7/M9/N2/N4/R1
1.4 M8/R2/T3/67/68
20-010 EFF DATE: 11-01-03
+ 20-TTT
-
20-2472 * ENG. COOLANT THERMOSTAT - (COOLANT DRAINED), R & R / REPL. .0 H2
.2 C0/G0/20/25/30/40
80
H1/H3/H4/H5/P1/P2
P3/P4/Q2/Q4/S1/S2
S3/S4/S5/S6/56/57
61/62/63/64/65/74
75/78/79
.3 A1/A5/B1/B2/E1/E2
E3/E4/E5/E6/E7/E8
E9/F1/F2/P5/Q1/T1
T2/T4/T5/U1/U2/U3
U4/91/95/98
.4 A2/A3/A7/A8/B3/B7
B8/J1/M1/M2/M3/M4
M5/M6/M7/M9/N1/N2
N3/N4/N5/Q3/R1
.5 M8
.6 R2/T3/92/93/96
.8 A4/A9/B4/B9/51/52
53/54/55/71/72/73
94/97
1.0 67/68
20-011 EFF DATE: 11-01-03
+ 20-TTT
-
COOLANT THERMOSTAT HOUSING/COVER
--------------------------------
20-2720 * THERMOSTAT HOUSING - ENG. COOLING SYST., R & R / REPL. .0 N1/N3/N5
(SEE ALSO 20-2900) - 123 MODEL WITH YORK A/C COMPRESSOR .4 P3/P4/Q4
.8 41/44/47
.9 P7/P8/P9/Q2/U1/U2
U3/U4
1.0 30
P1/P2/P6/R1/S1/S2
S3/S4/S5/S6/21/56
1.1 C1/C4/C7/Q1/22/23
1.2 G1/G2
1.3 M0
J1/N2/N4/P5
1.4 R2/T3
1.5 A4/A9/B4/B9/Q3/R3
1.6 94/97
20-2900 * ADDL. TO OPER. NO. 2720 - VEH. WITH YORK A/C COMPRESSOR 1.3 21/31/32/33
20-3010 * THERMOSTAT HOUSING COVER - COOLING SYST., R & R / REPL. .4 C1/C2/C3/C4/G1
.5 25/40/80
A1/A5/B1/B2/57/61
62/63/64/65/74/75
78/79/91/95
.6 20/30
1.0 11/12/15/51/52/53
54/55/71/72/73/92
1.3 13/14
20-012 EFF DATE: 11-01-03
+ 20-TTT
-
20-3012 * THERMOSTAT HOUSING COVER - (COOLANT DRAINED), R & R / REPL. .2 25/40/80
A1/A5/B1/B2/C1/C2
C3/C4/G1/56/57/61
62/63/64/65/74/75
78/79/91/95
.6 11/12/15/51/52/53
54/55/71/72/73/92
ENG. COOLANT TEMP. SWITCH - FOR TEMP. GAUGE
-------------------------
20-3710 ENGINE COOLANT TEMP. SWITCH - FOR TEMP. GAUGE, REPL. .0 M4/M9/N1/N3/N4
(AFTER TEST) .3 J1/M1/M2/M3/M5/M6
M7
.5 N2
.7 U1/U2/U3/U4
.8 M8
20-3732 ENGINE COOLANT LEVEL SENDER, REPLACE .3 N0
(AFTER TEST) R0
20-013 EFF DATE: 11-01-03
+ 20-TTT
-
ENGINE COOLANT LEVEL SENSOR
---------------------------
20-3733 ENGINE COOLANT LEVEL SENSOR, REPL. .0 N2/N4
(COOLANT DRAINED) .2 40/50/70/90
P0/Q0/T1/T2/T3/T4
T5/U1/U2/U3/U4/15
.3 A0/B0/C0/E0/G0/H0
M0/25/60/80
F1/F2/J1/N1/N3/N5
R0/S1/S2/S3/S4/S5
S6
RADIATOR & CAP
--------------
20-014 EFF DATE: 11-01-03
+ 20-TTT
-
20-3865 * RADIATOR, R & R .0 C6
(SEE ALSO 20-4300) - AUTOM. TRANSM. OPTIONAL .8 41/42/43/47
.9 20/30
62/63/64/65
1.1 A1/A5/B1/B2/C1/C4
1.2 25/50/70/80
61/94/97
1.3 10
C7/E2/G1/G2/G3/G4
1.4 A4/A9/B4/B9/44/45
46
1.5 A2/A3/A7/A8/B3/B7
B8/C2/C3/E3/E6/E9
1.6 E1/S5/S6/91
1.7 U2/U3
1.8 E5/J1/M1/M2/M3/M5
M6/M7/M9/N1/N3/N5
U1/U4/67/68/92/93
95/96
1.9 P1/P2/P3/P4/Q2/Q4
S1/S2/S3/S4
2.0 T2/T5
2.1 T1/T4/98
2.2 C5/E7/E8/H1/H3/R1
T3
2.3 E4/F1/F2/H2/H4/H5
2.4 R2
3.0 P5
3.1 Q3
3.2 Q1
4.2 M4/N2/N4
4.5 M8
20-015 EFF DATE: 11-01-03
+ 20-TTT
-
20-4000 * RADIATOR, REPL. .0 C6
(SEE ALSO 20-4300) - AUTOM. TRANSM. OPTIONAL .8 41/42/43/47
.9 20/30
62/63/64/65
1.1 A1/A5/B1/B2/C1/C4
1.2 25/50/70/80
61/94/97
1.3 10
C7/E2/G1/G2/G3/G4
1.4 A4/A9/B4/B9/44/45
46
1.5 A2/A3/A7/A8/B3/B7
B8/C2/C3/E3/E6/E9
1.6 E1/S6/91
1.8 E5/U2/U3/67/68/92
93/95/96
1.9 P1/P2/P3/P4/P6/P7
P8/P9/Q2/Q4/S1/S2
S3/S4/S5/U1/U4
2.0 J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5
2.1 T2/T5/98
2.2 C5/E7/E8/H1/H3/T1
T4
2.3 E4/F1/F2/H2/H4/H5
R1/T3
2.4 R2
3.0 P5
3.1 Q3
3.2 Q1
4.3 M4/N2/N4
4.6 M8
20-4300 * ADDL. TO OPER. NO. 3865/4000 - VEHICLES WITH AUTO TRANS .3 C1/C2/C3/C4/C7/E1
E2/G1/G2/G3/G4/P1
P5/Q1/Q2/Q3/Q4/T1
T2/T3/T4/T5/41/42
43/45/47/91
20-016 EFF DATE: 11-01-03
+ 20-TTT
-
20-4390 RADIATOR/RESERVOIR FILLER CAP, REPL. .1 00
RADIATOR SIDES AND BOTTOM COVERING
----------------------------------
20-4510 RADIATOR SIDE COVERING - LEFT, R & R / REPL. .2 25/80
74/75
.3 40
20-4520 RADIATOR SIDE COVERING - RIGHT, R & R / REPL. .2 25/80
.3 40
20-4535 RADIATOR COVERING, BOTTOM - (BUMPER REMOVED), R & R / REPL. .2 25/40/80
20-017 EFF DATE: 11-01-03
+ 20-TTT
-
COOLANT EXPANSION TANK
----------------------
20-4950 * ENGINE COOLANT EXPANSION TANK (RESERVOIR), REPL. .4 C7
.7 G0
COOLANT OVERFLOW TANK
---------------------
20-5410 * ENGINE COOLANT OVERFLOW TANK, R & R / REPL. IF REQ. .0 H0/N0
.0 J1
.3 90
.4 62/63/64/65/89
.5 E0
F1/F2
.6 M0
C2/C3/C5/C6
.7 S1/S2/S3/S4/S5/S6
45
.8 A0/B0/25/70
P0/Q0/T3/U1/U2/U3
U4/15/46/57/67/68
82/83/84/85/88
.9 R0/T1/T2/T4/T5
1.1 81/86/87
20-018 EFF DATE: 11-01-03
+ 20-TTT
-
ENGINE BLOCKHEATER/CABLE
------------------------
20-5470 * ENGINE BLOCK HEATER WITH CABLE, REPL. .0 C7/96
.9 42/43/46
1.0 G1/G2
1.2 E1
1.4 A1/B1/B2/E5/E6/E7
E8/E9/92
1.5 E4/F1/F2/56/57/78
79
1.7 25/80
31/35/36/37
1.8 A5/C2/C3/E2/E3/41
44/45/47/62/63/64
65/74/75/91/95
1.9 A2/A3/A7/A8/67/68
93
2.1 A4/A9/B4/B9/94
2.2 51/52/53/54/55/71
72/73
3.2 11/15
5.1 C1/C4
20-019 EFF DATE: 11-01-03
+ 20-TTT
-
20-5480 * ENGINE BLOCK HEATER AND CABLE, SUBSEQUENT INSTALLATION .0 C6/C7/N2/N4/R1/R2
.0 U0/96
1.0 G1/G2
1.2 42/43/46
1.4 A1/B1/B2
1.5 M0
E1/E5/J1/N1/N3/N5
1.6 92
1.7 E4
1.8 C5/E6/E7/E8/E9/F1
F2/56/57/78/79
1.9 A2/A3/A7/A8/B3/B7
B8/93
2.0 25/80
C2/C3/E2/E3/44/45
62/63/64/65/67/68
74/75/91/95
2.1 A4/A9/B4/B9/94
2.5 51/52/53/54/55/71
72/73
2.6 41/47
3.3 11/15
5.2 C1/C4
20-5490 * ENGINE BLOCKHEATER CABLE, SUBSEQUENT INSTALLATION .3 A5/E1/E5/43/46/57
61/78/79/81/86/87
2.0 E2/E3
20-020 EFF DATE: 11-01-03
+ 20-TTT
-
ENGINE COOLING FAN
------------------
20-5660 * ENGINE COOLING FAN BLADE, REPL. .0 C5/C6/G3/H2
.3 E0
C1/C4/C7/F1/F2/G1
G2/41/42/44/47
.5 A5/21/31
.6 25/80
C2/C3/15/61/62/63
64/65
.7 B0/90
A1/A2/A3/A4/A7/A8
A9/43/46/57/74/75
78/79
.8 32/33/34/35/36/37
51/52/53/54/55/56
71/72/73
1.1 11/12/13/14
1.2 45
2.0 67/68
20-5664 * ENGINE COOLING FAN BLADE - (RADIATOR REMOVED), REPL. .0 C5/C6
.2 E0/G0/H0/25/60/80
90
C1/C2/C3/C4/C7/41
42/44/47
.3 A0/B0
43/45/46/57/78/79
20-021 EFF DATE: 11-01-03
+ 20-TTT
-
ENGINE COOLING FAN MOUNTING FIXTURE
-----------------------------------
20-5995 * ENGINE COOLING FAN MOUNTING FIXTURE, R & R / REPL. IF REQ. .0 C5/C6
.8 E4/E6/E7/E8/E9/F1
F2
1.2 A1/B1/B2/C2/C3/E2
1.3 74/75
1.4 25
62/63/64/65/82/83
84/85/88/89
1.6 91/95
1.7 A4/A9/B4/B9
1.8 92/93/96
2.2 E3
2.7 67/68
20-5998 * ENGINE COOLING FAN MOUNTING FIXTURE, R & R / REPL. IF REQ. .7 45
(RADIATOR REMOVED)
20-022 EFF DATE: 11-01-03
+ 20-TTT
-
ENGINE COOLING FAN CONTROL MODULE
---------------------------------
20-6000 * ENGINE COOLING FAN CONTROL MODULE, R & R / REPL. IF REQ. .0 C4/C5/N3/N5/S1/S2
.0 S3
.6 E0/G0
F1/F2
.7 H0
N1
1.3 M0
J1/N2/N4
20-6460 ENGINE COOLING FAN ASSEMBLY, REPLACE .0 R1/R2
.3 G0
1.0 T3
1.1 U1/U2/U3/U4
1.3 N1/N2/N3/N4/N5/T1
T2/T4/T5
20-6461 ENGINE COOLING FAN ASSEMBLY, R & R, REPLACE IF NECESSARY .0 N3/N4
1.0 M4/M8/T1/T2/T3/T4
T5
1.1 R2/S1/S2/S3/S4/S5
S6
1.2 N2/R1
1.3 P0/Q0
1.4 J1/M1/M2/M3/M5/M6
M7/M9
20-6462 ENGINE COOLING FAN ASSEMBLY, REPLACE .0 N3/N4/P0/Q0
(ENGINE COOLING FAN ASSEMBLY REMOVED) .3 N2/T1/T2/T3/T4/T5
U0
20-6463 ENGINE COOLING FAN ASSEMBLY, R & R / REPL. IF REQ. .0 N1/N3/N5
(RADIATOR REMOVED) .3 N2/N4
20-023 EFF DATE: 11-01-03
+ 20-TTT
-
20-6465 COMPONENTS -FAN UNIT (FAN UNIT REMOVED), REPLACE .3 S0
COOLING FAN COUPLING/VISCOUS FAN CLUTCH
---------------------------------------
20-6590 ENGINE COOLING FAN CLUTCH FUNCTION, CHECK .3 00
20-6600 * ENGINE COOLING FAN CLUTCH, R & R / REPL. .0 C5/C6/G3/G4
.3 E0
C1/C4/C7/F1/F2/G1
G2
.5 A5/43/46
.6 25/80
C2/C3/15/61/62/63
64/65
.7 B0/90
A1/A2/A3/A4/A7/A8
A9/57/74/75/78/79
.8 22/23/32/33/34/35
36/37/51/52/53/54
55/56/71/72/73
.9 41/42/44/47
1.1 11/12/13/14/45
2.0 67/68
20-6602 * ENGINE COOLING FAN CLUTCH, R & R / REPL. .3 A0/B0/25/60/80/90
(RADIATOR REMOVED) C1/C4/C7/43/45/46
57/74/75/78/79
.4 10
.5 C2/C3/41/42/44/47
51/52/53/54/55/56
71/72/73
20-024 EFF DATE: 11-01-03
+ 20-TTT
-
ENGINE COOLING FAN TEMP. SWITCH
-------------------------------
20-6721 TEMPERATURE SWITCH - FOR COOLING FAN COUPLING, REPL. .2 41
(AFTER COOLING FAN COUPLING FUNCTION TEST)
ENGINE COOLING FAN SHROUD
-------------------------
20-6800 * ENGINE COOLING FAN SHROUD, REPL. .0 C6/M4
.2 G1/G2
.3 A0/B0/E0/H0/25/60
80/90
C1/C2/C3/C4/C5/C7
F1/F2/G3/G4/21/31
41/42/43/44/47/74
75/78/79
.4 15/22/23
.5 50
32/33/34/35/36/37
45/46/71/72/73
1.1 11/12/13/14
20-025 EFF DATE: 11-01-03
+ 20-TTT
-
COOLANT HOSES - ENGINE
-------------
20-7440 * ENGINE COOLANT HOSES - ALL, REPL. .0 G0
(SEE ALSO 20-7741) - 123 MODEL WITH YORK A/C COMPRESSOR .0 M4/M8/N2/N4/R1/R2
.0 U0
.6 C1/C4/61/81/86/87
.7 A5/C2/C3/E1/E2/E5
57/78/79
.8 40
C5/E4/E6/E7/E8/E9
H1/H2/H3/H4/H5/H6
P0/Q2/Q4/S1/S2/S3
S4/S5/S6/T1/T2/T3
T4/T5/26/27/82/83
84/85/88/91/95/98
.9 A1/B1/B2/62/63/64
65/74/75/89
1.1 30
E3/21/56
1.5 A2/A3/A4/A7/A8/A9
B3/B4/B7/B8/B9/67
68/92/93/94/96/97
1.6 10
J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5/22
23/51/52/53/54/55
71/72/73
20-026 EFF DATE: 11-01-03
+ 20-TTT
-
20-7442 * ENGINE COOLANT HOSES, ALL - (COOLANT DRAINED), REPL. .0 G0
.0 M4/N2/N4/R1/R2/U0
.3 A5/57/61/78/79/81
86/87
.4 H0
C1/C2/C3/C4/E1/E2
E4/E5/E6/E7/E8/E9
T1/T2/T3/T4/T5
.5 C5/P0/Q2/Q4/82/83
84/85/88/91/95
.6 25/40
A1/B1/B2/J1/62/63
64/65/74/75/89
.7 M1/M2/M3/M5/N1/N3
N5
.9 30
E3/56
1.1 A2/A3/A7/A8/B3/B7
B8
1.2 10
51/52/53/54/55/71
72/73
1.3 A4/A9/B4/B9/92/93
94/96/97
20-7450 * ENGINE COOLANT HOSE - ONE (SPECIFY), REPL. .0 G0/N0
.0 R1/R2/U0
.4 20/30
C1/C2/C3/C4/41/42
43/44/46/47
.5 25/80
45
.6 A0/B0/E0/H0/10/50
60/70/90
C5/S1/S2/S3/S4/S5
S6/T1/T2/T3/T4/T5
20-027 EFF DATE: 11-01-03
+ 20-TTT
-
20-7741 * ADDL. TO OPER. NO. 7440 - WITH YORK A/C COMPRESSOR 1.4 31/32/33
COOLANT HOSES - HEATING SYSTEM
-------------
20-8240 * COOLANT HOSES, ALL - HEATING SYSTEM, REPL. .0 A0/B0/C0/E0/G0/H0
.0 N0
.0 R1/R2/T1/T2/T3/94
.0 97/98
1.1 20/30
1.2 40
1.7 50
71/72/73/78/79
1.9 25/60/80
2.0 13/14
3.0 74/75
5.8 91/92/93/95/96
20-8242 * HEATING SYST. COOLANT HOSES, ALL - (COOLANT DRAINED), REPL. .0 A0/B0/C0/E0/G0/H0
.0 N0
.0 R1/R2/94/97/98
.8 40
1.4 50
71/72/73
1.5 25/60/80
2.6 74/75
5.5 91/92/93/95/96
20-8290 * COOLANT HOSE (SPECIFY) - HEATING SYSTEM, REPL. .0 A0/B0/C0/E0/G0/H0
.0 N0/10/20/25/30/40
.0 50/60/70/80/90
.0 F0/R0/S0/T0
20-028 EFF DATE: 11-01-03
+ 20-TTT
-
COOLANT HOSES - FOR WINDSHIELD HEATER
-------------
20-8852 * COOLANT HOSES, ALL - WINDSHIELD HEATING SYSTEM, REPL. 1.6 50/70
20-8860 * COOLANT HOSE(ONE) FROM .. TO ... - WINDSHIELD HEATING, REPL. .5 50/70
COOLANT PIPE/LINE - ENGINE COOLING SYST.
------------ ----
20-9130 COOLANT LINE - THERMOSTAT TO RADIATOR, R & R/SEAL/REPL. .0 N1/N2/N3/N4
1.0 R1
1.1 R2
20-9133 COOLANT HOSE-THERMOSTAT HOUSING TO RADIATOR,R&R/SEAL/REPL. .0 M4/M8/N2/N4/T1/T2
(COOLANT DRAINED) .0 T3
.3 J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5
20-9220 COOLANT LINE - WATER PUMP TO RADIATOR, R & R/REPL.IF NEC. .0 N1/N2/N3/N4
.9 R1
1.1 R2
20-029 EFF DATE: 11-01-03
+ 20-TTT
-
CONNECTOR FOR HEATER HOSE - AT CYL. HEAD
-------------------------
20-9430 * COOLANT OUTLET ON CYL. HEAD - TO HEATING SYST., SEAL / REPL. .0 A0/B0/C0/G0/N0/60
.0 E1/E2/E3/E5/T1/T2
.0 T3/89/98
.3 10/20/30/50
71/72/73/74/75/91
92/93/95/96
.5 45
.7 26/27/82/83/84/85
88
1.0 44
1.1 97
1.4 41/47
1.8 94
20-9431 COOLANT LINE CONNECTION FITTING, REPLACE .0 J1/M1/M2/M3/M4/M5
.0 M6/M7/M8/M9
1.3 P5/Q1
20-9460 * COOLANT INLET ON CYL. HEAD - FROM HEATING SYST.,SEAL / REPL. .0 E0
.0 C1/C2/C3/C4/C7/F0
.0 G1/G2
.5 A5/15/57/78/79
.6 42/43/46/61/81/86
87
20-030 EFF DATE: 11-01-03
+ 20-TTT
-
COOLANT OVERFLOW FITTING ON RADIATOR
------------------------------------
20-9472 COOLANT OVERFLOW FITTING - AT RADIATOR, REPL. .2 25/60
(ENG. COOLANT DRAINED) 74/75/82/83/84/85
88/89
20-031 EFF DATE: 11-01-03
+ 20-XXX
-
20 0000 <JOBS IN GROUP 20 INCLUDE OPERATION(S) AS REQ.: >
ENGINE COOLANT, CHECK FOR PROPER ANTIFREEZE PROTECTION
COOLING SYST., PRESSURE TEST & CHECK FOR LEAK (AFTER REPAIR)
ACCESSIBLE HOSE CLAMPS, TIGHTEN
ANTIFREEZE-WATER RATIO, CORRECT (COOLANT DRAINED)
<JOBS IN GROUP 20 DO NOT INCLUDE OPERATION(S) FOR: >
ENGINE COMPARTMENT PANEL(S) - BOTTOM, R & R WHERE/WHEN REQ.
0______________________________________________________________________________________________________
0 20 1010 +INCLUDES:
COOLANT LEVEL, CHECK / CORRECT
0______________________________________________________________________________________________________
20-X001
+ 20-XXX
-
20 1030 +INCLUDES:
ENG. COOLANT THERMOSTAT COVER, R & R (TWICE)
ENG. COOLANT THERMOSTAT, R & R
FLUSHING DEVICE, C & D
+AFTER INSPECTION:
ENG. COOLANT THERMOSTAT/GASKET, REPL.
+DOES NOT INCLUDE:
ENG. COOLANT, REPL. AND CHECK FOR LEAK(S)
0______________________________________________________________________________________________________
0 20 1140 +INCLUDES:
COOLANT, DRAIN FROM RADIATOR AND ENGINE
0______________________________________________________________________________________________________
0 20 1150 +INCLUDES:
ENG. COOLANT, DRAIN AS NEC.
20-X002
+ 20-XXX
-
20 1290 +INCLUDES:
BATTERY GROUND CABLE, D & C AT BATTERY
COOLANT, DRAIN FROM RADIATOR AND ENGINE / REFILL
COOLING FAN AND SHROUD, R & R
BELT(S), LOOSEN & TIGHTEN OR R & R / ADJUST
PULLEY(S), R & R AS NEC.
COOLANT HOSES/PIPES, D & C AS REQ.
AUTOM. TRANSM. OIL COOLER LINES, D & C WHERE REQ.
AUTOM. TRANS. OIL LEVEL, CORRECT AFTER REPAIR
OPERATIONS LISTED WITH INCLUDED TEXT 20-0000 AS REQ.
<107 MODEL INCLUDES ADDITIONALLY: >
RADIATOR, R & R
AIR CLEANER, R & R
HIGH VOLTAGE DISTRIBUTOR, R & R
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R
DWELL ANGLE AND IGN. TIMING, ADJ. <(450 SL/SLC)>
<124 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER/DUCT, R & R <(103/104 ENG.)>
RADIATOR, R & R <(119/603 ENG.)>
COOLING FAN CARRIER, R & R <(119 ENG.)>
BELT TENSIONER, R & R <(104/119 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
P. STEERING PUMP, D & C W. HOSES CONNECTED <(103/104 ENG.)>
A/C COMPR., D & C WITH REFRIGE. HOSES CONNECTED <(103 ENG.)>
<126 MODEL INCLUDE ADDITIONALLY: >
AIR CLEANER/DUCT, R & R
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(116/117 ENG.)>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(103 ENG.)>
A/C COMPR., D & C WITH REFRIGE. HOSES CONNECTED <(103 ENG.)>
HIGH VOLTAGE DISTRIBUTOR, R & R / ADJUST <(116/117 ENG.)>
20-X003
+ 20-XXX
-
<129 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER/DUCT, R & R
BELT TENSIONER, R & R
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(104 ENG.)>
COOLING FAN CARRIER, R & R <(119 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
<140 MODEL INCLUDES ADDITIONALLY: >
RADIATOR, R & R <(120 ENG.)>
BELT TENSIONER, R & R <(104 ENG.)>
COOLING FAN CARRIER, R & R <(119 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119/120 ENG.)>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(104 ENG.)>
<170 MODEL INCLUDES ADDITIONALLY: >
AIR COOLER OUTLET PIPE, R & R
POWER STEERING PUMP, D & C WITH HOSES CONNECTED
BELT TENSIONER, R & R
ENG. OIL DIPSTICK TUBE, R & R
<201 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER/DUCT, R & R <(190E 2.6)>
FRONT BUMPER, R & R <(190E 2.6)>
A/C CONDENSOR, D & C AT RADIATOR <(190E 2.6)>
RADIATOR, R & R <(190E 2.6)>
COOLANT FAN MAGNETIC CLUTCH, R & R <(102/601 ENG.)>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(190E 2.6)>
A/C COMPR., D & C WITH REFRIGE. HOSES CONNECTED <(190E 2.6)>
BELT TENSIONER, LOOSEN / TIGHTEN
GENERATOR, LOOSEN / MOVE ASIDE / REINSTALL <(102 ENG.)>
20-X004
+ 20-XXX
-
<202 MODEL INCLUDES ADDITIONALLY: >
<C280>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED
BELT TENSIONER, R & R
ENG. OIL FILLER TUBE, R & R
<210 MODEL INCLUDES ADDITIONALLY: >
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(104 ENG.)>
BELT TENSIONER, R & R <(104 ENG.)>
COOLING FAN CARRIER, R & R <(119 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
+AFTER INSPECTION:
DISCONNECTED COOLANT HOSES, REPL.
DISCONNECTED TRANSM. OIL COOLER HOSES, REPL.
COOLANT HOSE - BY-PASS SYSTEM, REPL. <(103 ENG.)>
FAN BELT(S), REPL.
THERMOSTAT/SEAL, REPL. IF REQ.
COOLANT PUMP INLET HOUSING GASKET,REPL.<(116/117/119 ENG.)>
+DOES NOT INCLUDE:
COOLANT PUMP HOUSING, REPL. <(WHERE APPLICABLE)>
COOLANT PUMP SLIDE-RING SEAL, REPL.
0______________________________________________________________________________________________________
0 20 1295 +INCLUDES:
BELT(S), LOOSEN & TIGHTEN OR R & R / ADJUST
COOLING FAN, R & R
BELT/COMPONENT PULLEYS, R & R AS REQ.
OPERATIONS LISTED WITH INCL. TEXT 20-0000 AS REQ.
20-X005
+ 20-XXX
-
<107 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER, R & R
HIGH VOLTAGE DISTRIBUTOR, R & R / ADJUST
DWELL ANGLE / TIMING, CHECK / ADJ <(450 SL/SLC)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R
<124 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER/DUCT, R & R <(103/104 ENG.)>
COOLING FAN, CARRIER, R & R <(119 ENG.)>
BELT TENSIONER, R & R <(104/119 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
HEATER RETURN PIPE, D & C / REPL. SEAL <(103/104 ENG.)>
P. STEERING PUMP,D & C WITH HOSES CONNECTED <(103/104 ENG.)>
A/C COMPR., D & C WITH REFRIGE. LINES CONNECTED,<(103 ENG.)>
<126 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER/DUCT, R & R
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(116/117 ENG.)>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(103 ENG.)>
HEATER RETURN PIPE, D & C / REPL. SEAL <(103 ENG.)>
A/C COMPR, D & C WITH REFRIGE. LINES CONNECTED <(103 ENG.)>
HIGH VOLTAGE DISTRIBUTOR, R & R / ADJUST <(116/117 ENG.)>
<129 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER/DUCT, R & R
COOLING FAN CARRIER, R & R <(119 ENG.)>
BELT TENIONER, R & R <(104 ENG.)>
HEATER RETURN PIPE, D & C / REPL. SEAL <(104 ENG.)>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(104 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
20-X006
+ 20-XXX
-
<140 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER/DUCT, R & R
BELT TENSIONER, R & R <(104 ENG.)>
COOLING FAN CARRIER, R & R <(119 ENG.)>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(104 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
HEATER RETURN PIPE, D & C /REPL. SEAL <(104 ENG.)>
<201 MODEL INCLUDES ADDITIONAALY: >
AIR CLEANER/DUCT, R & R <(103 ENG.)>
COOLANT PUMP MAGNETIC CLUTCH, R & R <(102/601 ENG.)>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(103 ENG.)>
A/C COMPR., D & C WITH REFRIGE. LINES CONNECTED <(103 ENG.)>
GENERATOR, LOOSEN / MOVE ASIDE / REINSTALL <(102 ENG.)>
<202 MODEL INCLUDES ADDITIONALLY: >
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(C280)>
OIL FILLER TUBE, D & C
BELT TENSIONER, R & R <(104 ENG.)>
COOLANT PIPE FOR OIL COOLER, R & R <(C280)>
<210 MODEL INCLUDES ADDITIONALLY: >
BELT TENSIONER, R & R <(104 ENG.)>
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(104 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
+AFTER INSPECTION:
DISCONNECTED COOLANT HOSES, REPL.
COOLANT HOSE - BY-PASS SYSTEM, REPL.
FAN BELT(S), REPL.
THERMOSTAT/SEAL, REPL. IF REQ.
COOLANT PUMP INLET HOUSING GASKET,REPL. <(116/117/119 ENG.)>
20-X007
+ 20-XXX
-
+DOES NOT INCLUDE:
COOLANT PUMP HOUSING, REPL. <(WHERE APPLICABLE)>
COOLANT PUMP SLIDE SEAL RING, REPL.
0______________________________________________________________________________________________________
0 20 1300 +INCLUDES:
COOLING FAN, R & R
BELT(S), LOOSEN & TIGHTEN OR R & R / ADJ.
BELT/COMPONENT PULLEYS, R & R AS REQ.
<107 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER, R & R
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R
HIGH VOLTAGE DISTRIBUTOR, R & R
<124 MODEL INCLUDES ADDITIONALLY: >
COOLING FAN CARRIER, R & R <(119 ENG.)>
BELT TENSIONER, R & R <(104/119 ENG.)>
HEATER RETURN PIPE, D & C / REPL. SEAL <(103/104 ENG.)>
POWER STEERING PUMP, R & R <(103/104) ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
A/C COMPRESSOR, R & R <(103 ENG.)>
<126 MODEL INCLUDES ADDITIONALLY: >
HIGH VOLTAGE DISTRIBUTOR, R & R <(116/117 ENG.)>
HEATER RETURN PIPE, D & C / REPL. SEAL <(103 ENG.)>
POWER STEERING PUMP , R & R <(103 ENG.)>
A/C COMPRESSOR, R & R <(103 ENG.)>
20-X008
+ 20-XXX
-
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(116/117 ENG.)>
<129 MODEL INCLUDES ADDITIONALLY: >
<ENGINE 104:>
AIR CLEANER, R & R
BELT TENSIONER, R & R
POWER STEERING PUMP, R & R
HEATER RETURN PIPE, D & C / REPL. SEAL
<119 ENG.:>
COOLING FAN CARRIER, R & R
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R
BELT TENSIONER DEVICE, R & R
<140 MODEL INCLUDES ADDITIONALLY: >
BELT TENSIONER, R & R <(ENG. 104)>
POWER STEERING PUMP, R & R <(ENG. 104))
COOLING FAN CARRIER, R & R <(ENG. 119)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(ENG. 119)>
<201 MODEL INCLUDES ADDITIONALLY: >
BELT TENSIONER, LOOSEN / TIGHTEN
COOLING FAN MAGNETIC CLUTCH, R & R <(ENG. 102/601)>
POWER STEERING PUMP, R & R <(ENG. 103)>
AC COMPRESSOR, R & R <(ENG. 103)>
HEATER RETURN PIPE, D & C / REPL. SEAL <(ENG. 103)>
GENERATOR, R & R <(ENG. 102)>
<202 MODEL INCLUDES ADDITIONALLY: >
POWER STEERING PUMP, D & C WITH HOSES CONNECTED <(C280)>
BELT TENSIONER, R & R <(C280)>
ENG. OIL FILLER TUBE, D & C
COOLANT PIPE FOR OIL COOLER, D & C <(C280)>
20-X009
+ 20-XXX
-
<210 MODEL INCLUDES ADDITIONALLY: >
BELT TENSIONER, R & R <(104 ENG.)>
COOLING FAN CARRIER, R & R <(119 ENG.)>
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R <(119 ENG.)>
+AFTER INSPECTION:
DISCONNECTED COOLANT HOSES, REPL.
COOLANT HOSE - BY-PASS SYSTEM, REPL. <(ENG. 103)>
FAN BELT(S), REPL.
THERMOSTAT/SEAL, REPL.
COOLANT PUMP INLET HOUSING GASKET, REPL.<(ENG. 116/117;119)>
+DOES NOT INCLUDE:
COOLANT PUMP SLIDE SEAL RING, REPL.
COOLANT PUMP HOUSING, REPL. <(WHERE APPLICABLE)>
0______________________________________________________________________________________________________
0 20 1514 +INCLUDES:
2301 A/C COMPRESSOR WITH BRACKET, LOOSEN / MOVE ASIDE WITHOUT
2900 DISCONNECTING REFRIGERANT HOSES / REINSTALL
7741
0______________________________________________________________________________________________________
20-X010
+ 20-XXX
-
20 1535 +INCLUDES:
INTAKE MANIFOLD, R & R AS NEC.
<NOTE: >
OPER. NO. APPLIES ONLY WHEN THE REAR BOLT (MANIFOLD SIDE)
COULD NOT BE REMOVED UNDER NORMAL CONDITION
0______________________________________________________________________________________________________
0 20 1660 +INCLUDES:
COOLING FAN AND SHROUD, R & R
BELT TENSION, RELEASE / READJUST
+AFTER INSPECTION:
BELT(S), REPL.
0______________________________________________________________________________________________________
20-X011
+ 20-XXX
-
20 2155 +INCLUDES:
2156 <123 MODEL: >
OPERATION FOR "COOLANT PUMP, R & R"
CRANKSHAFT VIBRATION DAMPER, R & R <(110 ENG.)>
<124/126/201 MODELS: >
OPERATION FOR "COOLANT PUMP, R & R"
GENERATOR, D & C
GENERATOR CARRIER, R & R
THERMOSTAT COVER, R & R
AIR HOSE - AIR CLEANER TO TURBO, R & R
+AFTER INSPECTION:
DISCONNECTED COOLANT HOSES, REPL.
0______________________________________________________________________________________________________
0 20 2470 +INCLUDES:
2472 ENG. COOLANT, DRAIN AS NEC. / REFILL <(IN OPER. 2470)>
THERMOSTAT HOUSING COVER, R & R WITH HOSE CONNECTED
RUN ENGINE TO OPERATING TEMP., CHECK REPAIR FOR LEAK(S)
THERMOSTAT, CHECK FOR PROPER FUNCTION (AFTER REPAIR)
<124 MODEL 400-420/500 INCLUDE ADDITIONALLY: >
COOLING FAN SHROUD (UPPER PART), R & R
COOLING FAN, R & R
FAN BELT, D & C
20-X012
+ 20-XXX
-
20 2720 +INCLUDES:
ENGINE COOLANT, DRAIN / REFILL
SEALING SURFACE(S), CLEAN
RUN ENG. TO OPERATING TEMP., CHECK FOR LEAK(S) AFTER REPAIR
+AFTER INSPECTION:
THERMOSTAT / GASKETS, REPL.
THERMOSTAT HOUSING COVER, REPL.
DISCONNECTED COOLANT HOSES, REPL.
0______________________________________________________________________________________________________
0 20 3010 +INCLUDES:
ENGINE COOLANT, DRAIN AS NEC. / REFILL
COVER SEAL, REPL.
THERMOSTAT, REPL. IF REQ.
0______________________________________________________________________________________________________
0 20 3012 +INCLUDES:
COVER SEAL, REPL.
THERMOSTAT, REPL. IF REQ.
0______________________________________________________________________________________________________
20-X013
+ 20-XXX
-
20 3865 +INCLUDES:
4000 ENGINE COOLANT, DRAIN AS NEC. / REFILL
COOLANT HOSES, D & C
COOLING FAN SHROUD/SIDE COVERINGS, D & C
OIL COOLER, D & C WITH HOSES CONNECTED <(WHERE APPLICABLE)>
AUTOM. TRANSM. OIL COOLER LINES, D & C AT RADIATOR
AUTOM. TRANSM. OIL LEVEL, CORRECT
OPERATION LISTED WITH INCLUDED TEXT 20-OOOO AS REQ.
<129 MODEL INCLUDES ADDITIONALLY: >
A/C REFRIGERANT LINE, LOOSEN AT FRAME MEMBER/ REINSTALL
A/C CONDENSOR, D & C AT RADIATOR
UPPER RADIATOR SUPPORT, R & R
<170 MODEL INCLUDES ADDITIONALLY: >
UPPER RADIATOR SUPPORT, R & R
ENG. HOOD RELEASE CABLE, D & C
<201 MODEL INCLUDES ADDITIONALLY: >
UPPER RADIATOR SUPPORT, R & R <(190E 2.6/190D 2.5 TURBO)>
FRONT BUMPER, R & R
A/C CONDENSOR, D & C AT RADIATOR <(190E 2.6/190D 2.5 TURBO)>
<202/210 MODELS INCLUDE ADDITIONALLY: >
UPPER RADIATOR SUPPORT, R & R
ENG. HOOD RELEASE CABLE, D & C
+AFTER INSPECTION:
COOLING FAN SHROUD, REPL.
DISCONNECTED COOLANT HOSES, REPL.
DISCONNECTED TRANSM. OIL COOLER HOSES, REPL.
20-X014
+ 20-XXX
-
0______________________________________________________________________________________________________
0 20 4300 +INCLUDES:
TRANSM. OIL COOLER HOSES, D & C AT RADIATOR
TRANSM. OIL LEVEL, CORRECT
0______________________________________________________________________________________________________
0 20 4950 +INCLUDES:
ENGINE COOLANT, DRAIN AS NEC. / REFILL
W./WASHER FLUID RESERVOIR, LOOSEN / REINSTALL <(WHERE REQ.)>
COOLANT LEVEL SWITCH, TRANSFER / REPL. IF REQ.
0______________________________________________________________________________________________________
0 20 5410 +INCLUDES:
INNER FENDER COVER PANEL, R & R <(WHERE REQ.)>
0______________________________________________________________________________________________________
0 20 5470 +INCLUDES:
BLOCKHEATER AND CABLE, R & R
20-X015
+ 20-XXX
-
20 5480 +INCLUDES:
5490 WORK, PERFORM ACCORDING TO S.I. INFORM. AND WORK INSTRUCTION
0______________________________________________________________________________________________________
0 20 5660 +INCLUDES:
6600 FAN SHROUD, LOOSEN AND REINSTALL OR R & R (AS REQ.)
COOLING FAN WITH FAN CLUTCH, R & R
FAN CLUTCH ASSY., D & C AT FAN
<124 MODEL INCLUDES ADDITIONALLY: >
RADIATOR, R & R <(400-420/500)>
<201 MODEL INCLUDES ADDITIONALLY: >
<VEH. WITH ELECTROMAGNETIC FAN CLUTCH:>
BATTERY GROUND CABLE, D & C AT BATTERY
FAN BELT, R & R / REPL. IF REQ.
COOLANT PUMP PULLEY, R & R
SOLENOID BODY, D & C
<VEH. WITH VISCOUS FAN CLUTCH:>
RADIATOR UPPER CROSSMEMBER/SUPPORT, R & R <(190E 2.6)>
0______________________________________________________________________________________________________
0 20 5664 +INCLUDES:
COOLING FAN, R & R
FAN CLUTCH ASSY., D & C AT FAN
20-X016
+ 20-XXX
-
20 5995 +INCLUDES:
ENGINE COOLING FAN/SHROUD, R & R
FAN BELT, D & C
BELT TENSIONER PULLEY, TRANSFER
RUN ENGINE, CHECK FUNCTION
<103/104 ENGINES INCLUDE ADDITIONALLY: >
ENGINE COOLANT, DRAIN / REFILL / CHECK FOR LEAK(S)
HEATER RETURN PIPE, D & C AT COOLANT PUMP
<119 ENGINE INCLUDES ADDITIONALLY: >
RADIATOR, R & R <(MODEL 124, 400-420/500)>
<120 ENGINE INCLUDES ADDITIONALLY: >
UPPER OIL LINE, D & C
0______________________________________________________________________________________________________
0 20 5998 +INCLUDES:
ENGINE COOLING FAN, R & R
FAN BELT, D & C
HEATER RETURN PIPE, D & C AT COOLANT PUMP
BELT TENSIONER PULLEY, TRANSFER
0______________________________________________________________________________________________________
0 20 6000
0______________________________________________________________________________________________________
20-X017
+ 20-XXX
-
20 6602 +INCLUDES:
BATTERY GROUND CABLE, D & C AT BATTERY
FAN BELT(S), LOSSEN AND TIGHTEN / ADJ. WHERE REQ.)>
COOLING FAN, R & R
<201 MODEL INCLUDE ADDITIONALLY: >
<102/601 ENGINE:>
MAGNETIC FAN CLUTCH, R & R
+AFTER INSPECTION:
FAN BELT (SINGLE BELT DRIVE), REPL.
0______________________________________________________________________________________________________
0 20 6800 +INCLUDES:
COOLING FAN, R & R WHERE REQ.
+AFTER INSPECTION:
COOLING FAN, REPL. <(WHERE REMOVED)>
0______________________________________________________________________________________________________
0 20 7440 +INCLUDES:
7442 ENGINE COOLANT, DRAIN / REFILL <(IN 20-7740)>
AIR CLEANER, R & R
COOLANT SYSTEM, CKECK FOR LEAK(S) AFTER REPAIR
<116/117 ENGINES INCLUDE ADDITIONALLY:> >
20-X018
+ 20-XXX
-
WARM-UP REGULATOR, R & R
THERMOSTAT HOUSING COVER, R & R
+DOES NOT INCLUDE:
COOLANT PUMP, R & R FOR BY-PASS SYSTEM HOSE <(103 ENG.)>
COOLANT HOSES FOR ENG. OIL FILTER HEATER <(300SE/SEL)>
0______________________________________________________________________________________________________
0 20 7450 +INCLUDES:
8290 COOLANT, DRAIN AS NEC. / REFILL
COOLING SYSTEM, CHECK FOR LEAK(S) AFTER REPAIR
0______________________________________________________________________________________________________
0 20 8240 +INCLUDES:
8242 ENGINE COOLANT, DRAIN AS NEC. / REFILL <(IN 20-8240)>
AIR CLEANER, R & R
COOLING SYSTEM, CHECK FOR LEAK(S) AFTER REPAIR
<107 MODEL INCLUDES ADDITIONALLY: >
FRESH AIR GRILL, R & R
HEATER FAN COVER, R & R
MOLDINGS, R & R
BATTERY, R & R
AUX. COOLANT PUMP, R & R
<124 MODEL INCLUDES ADDITIONALLY: >
20-X019
+ 20-XXX
-
BATTERY, R & R
<126 MODEL INCLUDES ADDITIONALLY: >
ENG. COMPARTMENT CENTER PARTITION PANEL, R & R
AIR INLET GRILL (BELOW W/SHIELD), R & R
A/C MONO VALVE, R & R <(300SE/SEL)>
RELAYS AND HOLDER, R & R <(300SE/SEL)>
CONTROL MODULE & MOUNTING, R & R <(300SE/SEL)>
AUX. COOLANT PUMP, R & R
<129 MODEL INCLUDES ADDITIONALLY: >
AIR SCREEN - LEFT & RIGHT SIDE, R & R
ENG. COMPARTMENT CENTER PARTITION PANEL, R & R
RELAYS AND HOLDER, R & R
AUTOMATIC A/C MONO VALVE, R & R
AUX. COOLANT PUMP, R & R
DUST FILTER AND HOUSING, R & R
W/WIPER ASSEMBLY, R & R
CONTROL MODULE FOR ABS/ASR, R & R
<201 MODEL INCLUDES ADDITIONALLY: >
AIR SCREEN BELOW WINDSHIELD, R & R
0______________________________________________________________________________________________________
0 20 8852 +INCLUDES:
8860 AIR CLEANER, R & R
ENG. COMPARTMENT CENTER PARTITION PANEL - UPPER PART, R & R
20-X020
+ 20-XXX
-
20 9430 +INCLUDES:
ENGINE COOLANT, DRAIN AS NEC. / REFILL
AIR CLEANER, R & R WHERE REQ.
SEALING SURFACES, CLEAN
<201 MODEL INCLUDES ADDITIONALLY: >
AIR VALVE FROM HEATER CONNECTION, R & R <(ENG. 102.961)>
+AFTER INSPECTION:
<MODELS 107/123/126/129:>
DISCONNECTED COOLANT HOSE, REPL.
0______________________________________________________________________________________________________
0 20 9460 +INCLUDES:
ENGINE COOLANT, DRAIN AS NEC. / REFILL
0______________________________________________________________________________________________________